Product ID:FORMULA 124 NON-FLAMING (DRY) CHLORINATED ALKYD (SUP DAT)
MSDS Date:03/01/1998
FSC:8010
NIIN:00-146-0834
Status Code:A
MSDS Number: CJPJX

Emergency Phone: 206-244-8844

Info Phone: 800-727-9694

Cage: 6F266

Telephone: 206-244-8844

Cage: 6F266

MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (MINERAL

CAS: 64742-88-7

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: SKIN: THIS MATERIAL MAY
CAUSE IRRITATION, SENSITIZATION, OR DEFATTING OF SKIN UPON
PROLONGED OR REPEATED CONTACT. INHALATION: EXCESSIVE EXPOSURE TO
VAPORS OR SPRAY MIST MAY RESULT IN HE ADACHE, DIZZINESS, NAUSEA AND
LOSS OF CONSCIOUSNESS. SOME REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. EYES: THI S MATERIAL MAY BE AN EYE
IRRITANT.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO KNOWN
CARCINOGENS IN REPORTABLE QUANTITIES AS DEFINED BY ACGIH, OSHA,
NTP, IARC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS (SEE SAFE HANDLING AND USE INFORMATION).

First Aid:SKIN: PROMPTLY WASH WISH SOAP AND WATER. REMOVE AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH WITH LARGE
QUANTITIES OF WATER FOR AT LEAST 15 MINUTES AND SEEK MEDICAL
ATTENTION. INGESTIO N: DO NOT INDUCE VOMITING. KEEP PERSON WARM AND
QUIET AND GET MEDICAL ATTENTION. ASPIRATION OF MATERIAL INTO LUNGS
CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. INHALATION:
REMOVE VICTIM TO FRESH AIR IMMEDIATELY. IF RESPIRATORY SYMPTOMS
DEVELOP, SEEK MEDICAL ATTENTION AT ONCE.

Flash Point Method:TCC
Flash Point:=41.7C, 107.F
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEM/WATER FOG. USE THE
ABOVE/ANY CLASS B EXTING AGENT. WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIUM, BUT HELPFUL IN KEEPING ADJACENT CONTRS COOL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . EVACUATE AREA OF UNPROTECTED PERSONNEL. WEAR PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN
AIR AND MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT. OSHA:
COMBUSTIBLE.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. ABSORB SPILL WITH AN ABSORBENT MATERIAL SUCH AS SAWDUST,
VERMICULITE OR SAND, AND PLACE MATERIAL INTO A CLOSED CONTAINER. IF
LARGE SPILL, DIKE AREA TO P REVENT THIS MATERIAL FROM ENTERING
WATERSYSTEMS OR SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.

Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
AVOID PROLONGED OR REPEATED INHALATION OF HEATED VAPORS OR SPRAY
MIST. KEEP AWAY FROM HEAT OR OPEN FLAME. THIS MATERIAL MAY CAUSE
SENSITIZATION. DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT
ALLOW CONTAMINATED CLOTHING TO CONTACT SKIN.
Other Precautions:DO NOT WELD ON FULL OR EMPTY CONTAINERS. KEEP
CONTAINERS CLOSED WHEN NOT IN USE, AND PROPERLY LABELED.

Respiratory Protection:A NIOSH APPROVED CANISTER-TYPE RESPIRATOR MUST
BE WORN TO PREVENT THE INHALATION OF VAPORS OR SPRAY MIST WHEN THE
TLV OR PEL IS EXCEEDED.
Ventilation:GEN DILUTION IS REQUIRED DURING NORM USE. LOC VENT MAY BE
REQUIRED DURING CERTAIN OPERATIONS TO KEEP EXPOS LEVEL BELOW LIMS
LISTED IN INGS SECTION OF THIS MSDS.
Protective Gloves:CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER GLOVES
REQUIRED.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
TRADE NAME/PART #: INTERIOR SEMI-GLOSS ENAMEL. WASTE DISP METH: GROUND
HNDLG EQUIP TO PVNT SPKS. FOR FUTHER INFO CONT YOUR STATE/LOC WASTE
AGENCY/UNITED STATES ENVIRON PROT AGENCY'S RCRA HOTLINE (1-80
0-424-9346/1-202-382-3000). PHYSICAL/CHEM: WT/GALLON: 13.98 LBS;
REACTIVITY IN WATER: NIL; VOC: 330 G/L (LESS WATER).

Boiling Pt:>152.8C, 307.F
B.P. Text:307F - 387F
Vapor Pres:2.6 MMHG @ 20C
Vapor Density:HVR/AIR
VOC Pounds/Gallon:330
Viscosity:82-90 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:COLOR OF TINT, MILD ODOR.
Percent Volatiles by Volume:47.0

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME. IF PRODUCT
CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND TOXIC VAPORS.

Waste Disposal Methods:IF DISCARDED, THIS MATL & CONTRS SHOULD BE
TREATED AS HAZ WASTE BASED ON CHARACTS OF IGNITABILITY AS DEFINED
UNDER FED RCRA REGS (40 CFR 261). DISP OF THIS MATL/ITS CONTRS
REQUIRES COMPLIANCE W/APPLIC LABELING, PACKAGING & RECORDKEEPING
STDS. DISPOSE OF I/A/W LOC, STATE & FED AGENCIES. (SUP DAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:HAZARD CLASS: III. DOT: COMBUSTIBLE. UN NUMBER:
1263.

SARA Title III Information:PURSUANT TO TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372, THIS PRODUCT CONTAINS OR MAY CONTAIN A TOXIC CHEMICAL IN A
QUANTITY SUBJECT TO THE REPORTI NG REQUIREMENTS UNDER SECTION 313.
THISMATERIAL HAS BEEN CATEGORIZED AS HAVING THE FOLLOWING HAZARD(S)
AS DEFINED BY SARA TITLE III REGULATIONS (40 CFR 370): ACUTE, FIRE.
Federal Regulatory Information:EPA REGISTRATION NUMBER (IF APPLICABLE):
NOT APPLICABLE.
State Regulatory Information: